VIDEO: EU project results show promise for water reuse in oil & gas

VIDEO: EU project results show promise for water reuse in oil & gas

 

Adaptable plug&play system can provide fit-per-purpose water for reuse

Technology combo driven by Machine Learning can increase industrial reuse

Results have been released on the European-wide INTEGROIL project that set out to increase the amount of water that can be reused from water intensive industries, such as oil & gas, petrochemicals and others.

Bringing together 10 companies from seven countries and supported by the H2020 programme of the European Union, the €5 million project set out to couple together technologies to increase water reuse levels by 50 percent.

The partners included technology and engineering companies (Acciona Agua, LIKUID, APLICAT, Innotek21, BWA, REP), universities (URV), consultancies (2.-0 LCA Consultants), professional platforms (EDS) and oil sector companies (TÜPRAŞ).

 

Technology combination & Machine Learning

Over three years, the project conducted one pilot plant with two demonstration scenarios, racking up over 8500 demonstration hours and 12,960 cubic metres of reclaimed water.

The propose technology consists of the incorporation of different technologies, among them dissolved air flotation, polymer and ceramic membrane filtering, advanced oxidation processes, reverse osmosis and the addition of chemicals with a low environmental impact.

According to the project partners, the integrated solution is characterised by its “robustness, efficiency and sustainability, qualities that are required to take on challenges such as the extreme variability of water or its complex composition”.

Furthermore, a Decision Support System (DSS) based on Artificial Intelligent algorithms (Machine Learning) were able to implement and operate the most appropriate configuration of individual technologies depending on: the quality of the input water and the quality of the output water needed for a particular reuse application.

Project results

The results from the European INTEGROIL Project were presented during a seminar held in Madrid towards the end of May.

During the seminar the partners explained the different phases of the project over the last three years. The first phase was dedicated to the design and construction of a pilot plant that incorporates all the technologies, and the remaining time - in periods of 12 months- to testing in two different scenarios: the first representing conditions of crude oil extraction, the so-called “upstream scenario” in the desalination plant at La Tordera (Spain), and the second in the TÜPRAŞ refinery in Turkey, to demonstrate the “downstream” conditions.

The results obtained in both scenarios show that it is feasible to apply the technology of the INTEGROIL project to oil installations and extend this practice to other industries, fulfilling the quality requirements for the re-use of water for different purposes.

In terms of energy consumption, the current results oscillate around 3 kW/m3 although, as the project partners explained, work will continue to reduce this.

Replicating the solution

Started in 2016, the project is aligned with several of the priorities identified by the European Innovation Platform on Water (EIP Water), an initiative by the European Commission to promote the development of innovative solutions that contribute to solving the major challenges facing the water sector.

With the aim of evaluating the possibilities of the transfer and replicability of the solution, the project is supported by an advisory committee made up of experts from the oil sector and also from other vertical markets that experience problems in the treatment of complex water for later re-use.

Share your water technology stories with us
Do you have an innovation, research results or an other interesting topic you would like to share with the international water technology industry? The Aquatech website and social media channels are a great platform to showcase your stories!

Please contact our Sr Brand Marketing Manager Annelie Koomen.

Are you an Aquatech exhibitor?
Make sure you add your latest press releases to your Company Profile in the Exhibitor Portal for free exposure.

Annette Bos - Join the conversation in our LinkedIn Group!

 

Most read articles

Latest Video